Toyota / Lexus CV Axle Replacement - Passenger Side - Camry / Avalon / Sienna / RAV4 / Lexus ES
458.8 هزار بار بازدید -
5 سال پیش
-
This video will show you
This video will show you how to replace the passenger side split axle shaft typically found on Toyota passenger cars (i.e., Camry, Avalon, Highlander, ES300, ES330 & ES350). The customer had been complaining about wheel vibration coming from the passenger side front end after driving into a large pot hole. The wheel was not bent and the tires were found not to be damaged, out of round or balance. However, with both front wheels off the ground, the engine running and the car's transmission positioned in drive, axle wobbling in and out of its outer cv housing was visible. Either the axle was bent or the internal bearings or bearing cage were damaged from the pot hole experience.
Toyota's passenger side axle shaft design is consistent for the majority of their front wheel drive vehicles; therefore this procedure can be used on many of Toyota's vehicles. A 12 point 30 mm nut is used to secure the axle to the wheel hub. A 6 point 30 mm socket will not work as a substitute on this type of nut. Depending on the environment where the car resides (road salt in winter & moisture) will determine the ease with which the axle's splines will slide out of the wheel hub. Corrosion buildup between the axle splines and the wheel hub is typical and may require hammering the shaft end to force the splines loose from the wheel hub with either a heavy duty punch tool or a powered jack hammer. The center half shaft bearing support hanger is braced and bolted onto the engine block. This bearing is held in place by a 12 mm bolt and a large snap ring. The snap ring's protruding ears can be pinched using long needle nose pliers to move the ring out of its support groove. Afterwards, the center bearing can be removed from its support hanger using a long punch tool and hammer. The tip of the punch tool should be braced against inner cv joint housing. A series of hammer blows to the punch should slowly work out the center bearing from it support hanger.
If you'd like to make a donation to the channel, please follow the link below: https://paypal.me/HardlyMoving?locale...
Parts & Specialty Tools:
Castrol Transmax ATF/CVT Full Synthetic Universal Automatic Transmission Fluid, 1 Gallon
https://amzn.to/3vjIjll
Milwaukee M18 FUEL 18-Volt Lithium-Ion Cordless 1/2 in. High Torque Impact Wrench w/Friction Ring (1,400 lbs Torque!)
https://amzn.to/2NUtBhp
Milwaukee 48-11-1850 M18 Redlithium 5.0Ah Bat Pack
https://amzn.to/3sEQST7
Milwaukee M12 & M18 Replacement Battery Charger
https://amzn.to/3827MmR
Axle Nut Socket, 30 mm, 1/2 in Drive, 12 Point
https://amzn.to/2OLgbly
Axle Nut Socket, 32 mm, 1/2 in Drive, 6 point Deep
https://amzn.to/2rby1F5
Long Reach Needle Nose Pliers
https://amzn.to/2OLoU73
Toyota Sienna 1998 thru 2006 (Haynes Repair Manual)
https://amzn.to/3iXPXbF
Snap Ring Pliers
https://amzn.to/2qJPRyt
Cardone CV Half Shaft Assembly (with 3.0L V6 engine)
LEXUS ES300 1997-2001
TOYOTA AVALON 1997-2004
TOYOTA CAMRY 1997-2001
TOYOTA SIENNA 1998-2003
TOYOTA SOLARA 1999-2003
https://amzn.to/2LkFHvH
LEXUS ES300 2002-2003
LEXUS ES330 2004-2006
LEXUS ES350 2007-2012
LEXUS RX330 2004-2006
LEXUS RX350 2007-2009
TOYOTA AVALON 2005-2016
TOYOTA CAMRY 2002-2017
TOYOTA HIGHLANDER 2004-2007
TOYOTA SOLAR 2004-2008
https://amzn.to/2P6z4hL
If the axle cv bearings, cage and shaft are not damaged, you can re-boot and grease your existing cv axle:
Outer CV Replacement Boot
LEXUS ES300 1997-2001
LEXUS RX330 2004-2006
LEXUS RX350 2007-2009
TOYOTA AVALO 1998-2002
TOYOTA CAMRY 1997-2001
TOYOTA COROLLA 2009-2010
TOYOTA HIGHLANDER 2010-2013
TOYOTA MATRIX 2009-2013
TOYOTA SIENNA 1998-2002
TOYOTA SOLAR 1999-2002
https://amzn.to/2DOtHhR
Outer CV Replacement Boot
TOYOTA AVALON 2003-2004
TOYOTA CAMRY 2002-2006
TOYOTA COROLLA 2005-2006
TOYOTA HIGHLANDER 2003-2007
TOYOTA MATRIX 2003-2006
TOYOTA RAV4 2003-2005
TOYOTA SIENNA 2003-2006
TOYOTA SOLARA 2002-2006
https://amzn.to/2rVsjaH
Outer CV Replacement Boot
LEXUS ES350 2007-2018
LEXUS HS250H 2010-2012
LEXUS NX200T 2015-2017
LEXUS NX300 2018
LEXUS RX300 1999-2003
LEXUS RX330 2004-2006
LEXUS RX350 2007-2009
TOYOTA AVALON 2005-2018
TOYOTA CAMRY 2008-2009
TOYOTA CELICA 1999-2005
TOYOTA HIGHLANDER 2001-2013
TOYOTA PRIUS 2010
TOYOTA RAV4 1996-2018
TOYOTA SIENNA 2007-2010
https://amzn.to/2PhdeYT
As an Amazon associate, I earn from qualifying purchases. Thank you for your support!
Please Subscribe: https://goo.gl/x6fySQ
#toyotacvaxle
Toyota's passenger side axle shaft design is consistent for the majority of their front wheel drive vehicles; therefore this procedure can be used on many of Toyota's vehicles. A 12 point 30 mm nut is used to secure the axle to the wheel hub. A 6 point 30 mm socket will not work as a substitute on this type of nut. Depending on the environment where the car resides (road salt in winter & moisture) will determine the ease with which the axle's splines will slide out of the wheel hub. Corrosion buildup between the axle splines and the wheel hub is typical and may require hammering the shaft end to force the splines loose from the wheel hub with either a heavy duty punch tool or a powered jack hammer. The center half shaft bearing support hanger is braced and bolted onto the engine block. This bearing is held in place by a 12 mm bolt and a large snap ring. The snap ring's protruding ears can be pinched using long needle nose pliers to move the ring out of its support groove. Afterwards, the center bearing can be removed from its support hanger using a long punch tool and hammer. The tip of the punch tool should be braced against inner cv joint housing. A series of hammer blows to the punch should slowly work out the center bearing from it support hanger.
If you'd like to make a donation to the channel, please follow the link below: https://paypal.me/HardlyMoving?locale...
Parts & Specialty Tools:
Castrol Transmax ATF/CVT Full Synthetic Universal Automatic Transmission Fluid, 1 Gallon
https://amzn.to/3vjIjll
Milwaukee M18 FUEL 18-Volt Lithium-Ion Cordless 1/2 in. High Torque Impact Wrench w/Friction Ring (1,400 lbs Torque!)
https://amzn.to/2NUtBhp
Milwaukee 48-11-1850 M18 Redlithium 5.0Ah Bat Pack
https://amzn.to/3sEQST7
Milwaukee M12 & M18 Replacement Battery Charger
https://amzn.to/3827MmR
Axle Nut Socket, 30 mm, 1/2 in Drive, 12 Point
https://amzn.to/2OLgbly
Axle Nut Socket, 32 mm, 1/2 in Drive, 6 point Deep
https://amzn.to/2rby1F5
Long Reach Needle Nose Pliers
https://amzn.to/2OLoU73
Toyota Sienna 1998 thru 2006 (Haynes Repair Manual)
https://amzn.to/3iXPXbF
Snap Ring Pliers
https://amzn.to/2qJPRyt
Cardone CV Half Shaft Assembly (with 3.0L V6 engine)
LEXUS ES300 1997-2001
TOYOTA AVALON 1997-2004
TOYOTA CAMRY 1997-2001
TOYOTA SIENNA 1998-2003
TOYOTA SOLARA 1999-2003
https://amzn.to/2LkFHvH
LEXUS ES300 2002-2003
LEXUS ES330 2004-2006
LEXUS ES350 2007-2012
LEXUS RX330 2004-2006
LEXUS RX350 2007-2009
TOYOTA AVALON 2005-2016
TOYOTA CAMRY 2002-2017
TOYOTA HIGHLANDER 2004-2007
TOYOTA SOLAR 2004-2008
https://amzn.to/2P6z4hL
If the axle cv bearings, cage and shaft are not damaged, you can re-boot and grease your existing cv axle:
Outer CV Replacement Boot
LEXUS ES300 1997-2001
LEXUS RX330 2004-2006
LEXUS RX350 2007-2009
TOYOTA AVALO 1998-2002
TOYOTA CAMRY 1997-2001
TOYOTA COROLLA 2009-2010
TOYOTA HIGHLANDER 2010-2013
TOYOTA MATRIX 2009-2013
TOYOTA SIENNA 1998-2002
TOYOTA SOLAR 1999-2002
https://amzn.to/2DOtHhR
Outer CV Replacement Boot
TOYOTA AVALON 2003-2004
TOYOTA CAMRY 2002-2006
TOYOTA COROLLA 2005-2006
TOYOTA HIGHLANDER 2003-2007
TOYOTA MATRIX 2003-2006
TOYOTA RAV4 2003-2005
TOYOTA SIENNA 2003-2006
TOYOTA SOLARA 2002-2006
https://amzn.to/2rVsjaH
Outer CV Replacement Boot
LEXUS ES350 2007-2018
LEXUS HS250H 2010-2012
LEXUS NX200T 2015-2017
LEXUS NX300 2018
LEXUS RX300 1999-2003
LEXUS RX330 2004-2006
LEXUS RX350 2007-2009
TOYOTA AVALON 2005-2018
TOYOTA CAMRY 2008-2009
TOYOTA CELICA 1999-2005
TOYOTA HIGHLANDER 2001-2013
TOYOTA PRIUS 2010
TOYOTA RAV4 1996-2018
TOYOTA SIENNA 2007-2010
https://amzn.to/2PhdeYT
As an Amazon associate, I earn from qualifying purchases. Thank you for your support!
Please Subscribe: https://goo.gl/x6fySQ
#toyotacvaxle
5 سال پیش
در تاریخ 1398/09/11 منتشر شده
است.
458,837
بـار بازدید شده